rv propane regulators fairview lp regulator regulator lp stage changeover rv enerco propane gas flame king picclick 253p bracket Wait a few minutes, and the regulator will reset itself. We travel full time in our RV and write about what we learn and share our experiences. It takes the pressure from the propane tanks down to a manageable level for the second stage of the regulator to do its job. 
There was a whoosh and smell of propane. Home Others RV Propane Regulator Troubleshooting & How to Guide.
This is a safety feature on propane tanks that is also known as a flow limiting device.
This is actually totally normal. Were Jenni and Jesse. I hope this was helpful in some way and you find the source of the propane smell in your trailer. tank propane regulator rv dual hose gas stage changeover camping camp w.c. 1/2 in. See Also:Best 2 Stage Dual Tank RV Propane Regulators Reviews. Its a $400.00 repair. The first thing is most likely moisture build-up inside your propane tank. It is possible for the rubber washers to get old and that could be part of the problem. I wish I hadnt scrapped the old Manchester depot. But if the heavy soot continues you may have a bad RV propane regulator. Test the connection again with the leak detector solution. It could be a damaged or dirty burner. Its most likely still covered under warranty.
Something similar to this I think, but Im not sure if this one is compatible with European regulators. To test the single stage regulator you could use a gas pressure tester like this (click to view on Amazon) to see what the pressure coming out of the regulator is to make sure its correct but if the regulator looks like its in good repair it should be fine. 6) I see there are RED (high volume) and GREEN handle (typically <160,000 BTU) pigtails. any advice would be great? Ive had to reseal threads twice before to get the amount of sealant just right.
So for a quick recap, to fix your problem I would change the propane regulator because it sounds like it is getting old and its probably time to get a new one because its letting moisture into your tank, and also refill your propane tanks with a winter propane mix to make sure any moisture in them gets removed. Make sure you are turning the valve to the propane tank on slowly. If the rubber washer inside looks fine it could be that the nut wasnt tightened enough. propane changeover One of the things that could be causing this is the propane tank being opened too fast after being connected to the regulator. I would try uncovering the vents and the exhaust pipe first and then maybe changing the propane regulator if that doesnt fix it. The gas supply piping may be under sized for the piping distance, number of elbows and fittings, or for the flow requirements of the appliances being served or for the regulator being tested. Thanks for advising me Mr Heater but he is the one that I just placed about a year ago, because I also had the Camco and the same thing happened. I have a 10 yr old Jayco Sterling. This was an issue I was having. The reason there are two different kinds of propane regulators is because both are connected to the same two stage regulator on one side. The vent helps the regulator breathe while it is being used and is also a safety feature in case the propane tank is overfilled and the pressure is getting too high. Just make sure you get replacement regulators that match the ones on your RV. Wait 5-10 minutes and turn the propane valve on exceptionally slowly. The stove is a great way to troubleshoot your RV propane regulator and a lot of these signs can be seen from a burner. It only expels gas if I dont use the appliances. This component fits between the propane tank and the rest of the propane system, and takes the fuel out the tank at high pressure and brings it down to a manageable level. If you see bubbles form anywhere turn off the gas and tighten the connection. If they are mostly yellow you dont have enough pressure in your LP gas system. Take a bowl or spray bottle and combine about 2 cups of water with around 2 or 3 tablespoons of dish soap. I am thinking it the Auto Propane switch over since both tanks work just fine when connected to a gas grill at home. If you hear popping noises when you turn off the flames on your RV stove burner then your propane regulator could be having issues. propane changeover fairview stage changover switchover Thanks in advance for your help! I wrote a post about it you can find here. We had the same issue and when we removed the metal cover on the outside furnace exhaust pipe it stopped flipping the sensor, and the furnace now works. propane changeover camco joetlc Next remove all the old yellow gas line tape from the main gas lines threads and re-tape it. propane 924n changeover 160k btu Make sure all the connections are airtight including the pigtails that go from the regulator to the propane tanks. The connection from the RV hose to the regulator base looks pretty gunked up and is sticky. will do this 2-3 times and then needs reset. Wait for about 10 minutes then reattach both or one of the propane tanks. If you mistakenly leave the regulator selector valve aimed straight down instead of fully right or left (like it should be), would that impede the flow of propane to your appliances or would you just loose the automatic switchover capability? My RV Regulator is leaking or hissing at the housing flange. changeover propane smartrving regulators I checked the furnace igniter which has a good strong arc so that appears to work correctly. RV propane sensor here (click to view on Amazon). Hard to say based on that, but I would definitely try changing the regulator before getting a new furnace. Hope this helps, good luck with the regulator. RV Water Hookup Filling The RV Fresh Water Tank Issue Fix. Is that normal or should I replace my regulator? Yes, the tank is placed horizontally, but the problem is that they are European tanks intended for powering vehicle engines, not for domestic use, and they have the STEAM outlet in the middle of the cylinder and not a little further up like the Manchesters. Our Norcold RV fridge is always giving us trouble as well. But if the heavy soot persists then you have a bad RV regulator. I recently had to change out a bad propane regulator on my travel trailer. Read flowing gas pressure at the pressure gauge or manometer with all of the gas-using appliance pilots lit and appliance gas burners operating. See Also:Is Your RV Fridge Not Cooling? Pull the cover off by hand to remove it. This is only for those who have dual propane tanks and an automatic RV propane regulator. I have a MEC Marshall MEGR-253 auto changeover Reg that I just installed new. Check the gas pressure. 7 Signs That Your RV Propane Regulator Has Gone Bad, 7 Common Signs of a Bad RV Propane Regulator, 7. Hi and thanks for sharing. Just got the RV Van last week. Propane regulators arent made to last forever. Popping noises can also be a sign of a damaged burner. Michael. A healthy propane flame shouldnt put off hardly any soot. Re-light all of the gas appliance pilots and turn the appliance on, confirming that the gas burners are all operating at their highest setting. If your RV propane regulator needs replacing check out this review of some of the best regulators on the market today. Hope this was helpful, good luck with your camper. I have an old 1985 lance cab over camper. Luckily we were near a store that sold RV propane regulators and we were able to switch it out before the old one stopped working altogether. Normally if left pointed straight down the regulator will pull propane from each tank simultaneously which doesnt impede the flow of propane so long as both tanks are open. Turned the propane tanks on. Then go inside your RV and light one of the burners on your stove so that you empty the LP gas in the line. It may seem obvious but if no propane is flowing through the regulator thats a problem. This is the lock-up gas pressure. And, it could be that the Suburban SW12DEL Water Heater might also be running which draws 12,000 BTUs per hour. bill. propane regulator rv regulators stage changeover camco double I bought a travel trailer and I am getting a gas smell during the day. Do not twist the main gas line. Make sure you use plenty of tape for a good seal and dont cross-thread nut onto the bolt. Does anyone know if there are regulators with greater capacity or that hold a little longer? Using a paintbrush, generously apply the soapy solution on the propane regulator. For a snug leak-free fit, tighten using the two crescent wrenches. To understand how an RV propane regulator works, you first need to understand what happens in each stage. 2. To remove it, place a wrench on the nut of the main gas line and twist the regulator. If you are having issues with your RV propane regulator, you can try to reset the regulator to see if the problem resolves. Will that work? Popping noises from the furnace burner is not a good sign.
You can get a replacement for an RV propane sensor here (click to view on Amazon). These regulators have a life of about 10 years and can start malfunctioning because they are too old. If your RV propane regulator has plastic rain cover over the front part you will need to remove it to access the nut that is located at the bottom of the regulator so you can use a wrench. Sometimes bug spray can even set them off. Use tape that is made specifically for gas lines like this (click to view on Amazon). If after a brief initial pressure rise the gas pressure continues to increase with the appliances off, the regulator is defective and must be replaced.
Check the propane regulator. The safest way to find the correct one will be to have a propane technician replace it and adjust it accordingly. If you notice propane coming from the vent make sure you dont have an overfilled propane tank. Related Product: Did you knowRV Propane Detectors (click to view on Amazon) need to be replaced every 5-10 years?
We have a 42 Fifth Wheel with (2) 40# LP Bottles on board. If its happening on one burner but not on the others examine the problematic burner. Any suggestions or recommendations? I had a similar issue, check out this article here for info on a few things you can do to try and fix it yourself. Then with the burners in the off position, turn the propane valve on. One of the best options will probably be to find a newer model that has close to the same specifications. My other Marshall did not do that. If you are looking to replace an automatic 2-stage dual RV propane regulator, you will need the following items: Unhook them from the old regulator you are going to replace. Furnace ignites and cycles fine; powerful and will drive you out of trailer. To reset a propane regulator, follow these instructions: Gas regulators, when not performing optimally or fail, can lead to many hazardous situations such as the leakage of toxic gases into the atmosphere, or even the risk of explosions or fire. 1) Can you explain why there are two different types of regulators? This would include the connection between the regulator and the propane tank, the regulator and hose, and the hose and appliance. Soon after the regulator started having issues keeping the correct pressure and the burners on our stove started popping and the flames got weak. You may need to adjust the supply regulator to achieve that pressure. I removed the screw underneath the regulator completely to see if it is allowing gas through and it is but the gas didnt seem to have much pressure. Try This One Simple Trick. They hooked it up on the bench and it runs like its supposed to. I can keep the mice out and ants out but is all but impossible to keep the stink bugs out! Leave the gas tank gas valve open or on to keep providing gas pressure to the gas delivery system. The regulator is attached to the main gas line that is connected to it on the bottom. That means you either have a leak in your propane system or the regulator needs replacing. Compare to desired pressure. Now slowly turn the valve on the propane tank until it is fully open. If the problem persists after the above steps, the regulator is bad and needs to be replaced. stage rv regulator propane flame king gas kit changeover pigtails So I pulled out the solenoid along with the LP gas tray to clean that out as well. My problem is the stove wont light yet everything else using propane works fine. Im not super familiar with propane run generators so I hesitate to give any advice on whether you should use a higher btu regulator or not. It sounds like a damaged seal, RV regulators dont last forever and it sounds like you might be due for a new one. As for the questions about the generator and the propane. My son and I were camping last weekend. i just filled both lp tanks, and replaced the 12v deep cycle battery. So long as you have checked all connections and havent found any leaks you should be fine. The flame on any of your propane RV appliances should be a strong blue. The regulator engages a safety valve, shutting it off when it detects a high propane flow. Other items that are on-board (typically not running at the same time) are: Atwood Stove (Ft Burner: 9,000 BTUs. Do I Need To Use RV Water Pump When Connected To City Water? Any thoughts? Is that normal ? or does it stay green all of the time? The mixture should cover the O-ring and the connecting point of the hose and valves. Thanks for any info!! You can use another wrench on the lower part if you are having difficulties twisting the regulator. For some reason taking off that outer metal cover and keeping the inside floor vents open and unobstructed has fixed the problem. Gas flows great from the right tank but when I switch to the other tank, no gas flow. The regulator output capacity is inadequate. This is also where we share our favorite RV and camping-related gear and accessories. It is a Marshall Gas Controls, Model # R3494 650,000BTU, Max Inlet 250 PSIG P.O.L, Outlet 10-14 in. Make sure yours is still up to date before your next camping trip. And finally, when I disconnected the (1) 40# propane bottle to switch it out while the generator was running, the generator starved for fuel again. Propane stove all burners on works fine flame looks good, fridge works fine. If the valve is opened too quickly it closes. Kept the silicone at the edges. If you are using a 2 stage propane regulator the fridge may be the problem. Theres a little vent on the bottom that causes the smell. My Cavagna auto change over regulator had the clear cover fall off while installing. You should see the gas pressure increase slightly (above the 11 inches of water column read before) and then the pressure rise should stop. Age can also be a factor when looking to establish if your propane regulator is going bad. Then we made sure all of the floor vents were open and didnt have anything covering them. fairview changeover Also, you will need a larger propane regulator for a tank of that size. Have you been able to light the stove before? Does this mean regulator is leaking or is not working properly. The appliances work fine with or without the silicone. If your propane auto changeover valve is not working, there could several possible causes for this. propane changeover Check to make sure the propane valve is ON. A strong propane smell may be a small crack or hole in the diaphragm of the propane regulator. Switched bottles across all possible variables; same result. The regulators also need to be a matching set and compatible with each other. To troubleshoot a propane auto changeover valve that is not working, follow these instructions: If your RV flow propane is not flowing, try the following troubleshooting tips to fix the issue: Check this too: Gas Fireplace Troubleshooting and How to Guide. It also could be that your fridge is trying to cool too much. To reset your propane regulator shut off both the propane tanks and unhook them from the regulator. Inside the regulator, there is a small valve that will detect propane gas moving too fast through the system. My camper is 10 years old and I have already replaced my refrigerator, because field mice got into and destroyed the circuit board, I have to place ant traps in the camper every spring and I have to clear the air/LP balance vent tube on the hot water heater annually because of stink bug infestation. RVs do run on a fairly low pressure system. And during the process, I learned a lot about regulators and how they function. Thank you for stopping by. Do the burners on the stove work? Once I have done this, is there a tape that should be used at this connection? The propane regulator is a crucial component of every RV gas system and if it is not working properly you will notice problems with your propane appliances. 5) Do I need to change the pigtail lines to match? We are compensated for referring traffic and business to these companies. Good luck with the fridge, feel free to ask if you have any more questions. It might have been put back on the wrong way. There is a vent located on the bottom of all propane regulators. When I pulled the igniter to check for spark a few days back I saw, with the help of a flash light, roasted stink bugs in the fire box. Once the threads are clean wrap a generous amount of the thread sealant tape around it.
If you hear popping noises when you turn off the flames on your RV stove burner then your propane regulator may be having issues. Its connected on 2 30lb tanks on my trailer. To reset the valve, turn off the propane tank valve and turn off all the propane appliances.
If you notice propane coming from the vent, make sure you dont have an overfilled tank. If the stove is working just fine but your water heater isnt lighting the problem is the water heater. Hi, I cant seem to get my gas working in my caravan. The same thing happens when I turn the heat on the AC thermostat. Check the excess flow valve in your propane tank. If any of the connections are leaking whether its the RV line to the propane regulator or the pigtails you are going to need to re-do the sealant on the threads. To test for a gas leak you can get a leak detector spray like this one (click to view on Amazon), or make your own using 1 part water and 1 part dish soap. i have replaced my furnace with a new core and its still doing the same thing the 20 year old 1 was.it lights 3 times and then goes into lockout.im thinking its a bad regulator but my other lp appliances work.since the furnace uses more propane than the other appliances could a bad regulator let the other ones work but not the furnace? Turn on the valve on the tank. The thing that worked for us is we took off the metal thing covering the exhaust pipe from the furnace on the outside of the RV, also check the exhaust pipe to make sure nothing is inside of it like a wasp nest. Maybe thats because the rest is original American. 3) Is the KPI Model 9000 Regulator a requirement? If it gets too hot, or not enough air, its not going to ignite and run. Hello, Im having trouble with my Dometic fridge. To troubleshoot this situation, turn off the propane tank valve and turn off all the propane appliances. The propane regulator could have gone bad and needs replacing. To fix this first turn off the propane tank and wait for a few minutes to let the regulator reset. Yes you can, we recently replaced our own RV propane regulator. I didnt know how the auto charge over worked so I switched to a full tank and then nothing would light.